Piston Slap: Take These Broken Wings Edition

Sajeev Mehta
by Sajeev Mehta

Frequent Piston Slap contributor Theodore writes:

I just put my 1992 Ford Thunderbird (V-6, stripper, ex-rental car) on craigslist, but I don’t know if I can really bring myself to part with it.

The automatic transmission is dying for the second time. Leaking badly, hesitates before going into gear, tries to downshift from fourth to third at 50-55mph, makes a weird sound that I can’t even describe except to say that it sounds like something is spinning way faster than it should. Its latest trick is a neat one: sometimes the whole front end will shudder while turning at low speed.

Is there any hope for the patient? Can the automatic be salvaged, or is a manual transplant possible? Practical? Sane?

And while I’m at it, here’s a Piston Slap “Nugget of Wisdom” for the B&B: Fords of that era equipped with automatic shoulder belts. When the motor eventually craps out, look in your owner’s manual, because Ford anticipated this failure and provided a backup that’s also a cheap fix. At the base of the B-pillar of my Thunderbird there is a little panel: behind that is the motor. The motor has a knob on the top. With some skinned knuckles, swearing, and shoving (carefully!) on the shoulder belt anchor, you can wind the anchor back to the locked position. Then you just pull the belt forward and slide under it when you get in and out of the car.

Sajeev replies:

You don’t know if you can bring yourself to part with a V6 Thunderbird? Seriously?

Regarding the transmission: many, many rebuilders can’t make freshened a Ford (or Mopar) transmission last longer than 2 years to save their lives. I don’t know why, but I reckon it has to do with training done on GM units. And a GM transmission this is not. If you are serious about this car, search the TCCOA forums and make friends with Blue Oval (i.e., Mustang) Pistonheads in your area: they’ll know a local shop that can actually fix a Ford transmission. Or bite the bullet and get a Ford or Jasper rebuilt unit.

Yes, there is hope for the patient. But you have to be nuts. Nuts like me, and my resto-modded 1988 Cougar XR-7. After thousands in rebuilding the suspension, brakes, steering, transmission, engine and new carpet and paint, the car is a head turner that will never leave my possession. You can do the same: plenty of Thunderbird Super Coupe/Lincoln Mark VIII parts are available for a healthy restomod on the MN-12 platform. Hell, just get a Mark VIII from Craigslist and do a complete sub frame swap, front and rear.

But I’d sell this one and find a Super Coupe in the same color. That’s much easier, cheaper and a far superior base to start with. Of course, I didn’t take my advice, so why should you?

Sajeev Mehta
Sajeev Mehta

More by Sajeev Mehta

Comments
Join the conversation
2 of 13 comments
  • MaintenanceCosts It's not a Benz or a Jag / it's a 5-0 with a rag /And I don't wanna brag / but I could never be stag
  • 3-On-The-Tree Son has a 2016 Mustang GT 5.0 and I have a 2009 C6 Corvette LS3 6spd. And on paper they are pretty close.
  • 3-On-The-Tree Same as the Land Cruiser, emissions. I have a 1985 FJ60 Land Cruiser and it’s a beast off-roading.
  • CanadaCraig I would like for this anniversary special to be a bare-bones Plain-Jane model offered in Dynasty Green and Vintage Burgundy.
  • ToolGuy Ford is good at drifting all right... 😉
Next