Consumer Reports Says EPA Fuel Economy Labels Are Pretty Accurate, Right Before the EPA Changes Them

Steph Willems
by Steph Willems

Barring those pesky instances where automakers were forced to hand cash to buyers as a make-nice gesture, the Environmental Protection Agency fuel economy labels found on window stickers are actually pretty accurate.

That’s the verdict from Consumer Reports’ just-released study on the real-world mileage of 2009-2016 model year vehicles, but it comes with an asterisk. Don’t break out the champagne just yet, EPA.

For its report, CR staged a repeat of its 2005 study of 2000-2006 model year vehicles. That study found a large difference between EPA gas mileage and real-world results (3.3 miles per gallon, on average), prompting the EPA to shake up its testing methodology. Amazingly, it turns out that vehicles often run the air conditioner, accelerate more briskly, and experience winter — things not accounted for in the pre-2008 methodology.

This time around, the EPA has earned a passing grade. CR found that on 397 vehicles, the difference between the regulator’s estimate and the results of its own testing amounted to just a 0.8 mpg difference.

Warning to the EPA: hold off on the celebrations. Of those vehicles tested, the difference in fuel economy ratings varied depending on engine type. According to CR, regular gasoline-powered vehicles fell below the EPA rating by an average of 0.7 mpg, while diesel models topped the rating by the same amount.

The biggest difference was seen on hybrid vehicles. For those models, the average gap between the label and real life rang in at 3.3 mpg — a 9.1 percent difference. When all said and done, 57 percent of vehicles tested by CR saw fuel economy lower than the EPA. Still, the publication noted that over 80 percent of the real-world fuel economy results were within 1 mpg of the EPA label.

The study comes just as the EPA rolls out its new fuel economy testing methodology for 2017 model year vehicles. Because the new tests reflect recent advances in fuel-saving technology, including hybrid technology, the EPA claims some vehicles that are mechanically unchanged since last year could see a lower fuel economy rating. Others, especially naturally aspirated trucks, aren’t likely to see any change.

[Image: Faris/ Flickr ( CC BY 2.0)]

Steph Willems
Steph Willems

More by Steph Willems

Comments
Join the conversation
3 of 23 comments
  • Anonymous Anonymous on Nov 15, 2016

    EPA testing in no way reflects real-world driving. Gallons per hour would be a very useful measure for a lot of the populace. I had an office in the Adelaide suburb of Dallas for many years. A regularly heard joke there was variations on I-630 traffic, the gist of which goes like this: A guy leaves his driveway at 7AM headed to his 8AM job. At 8AM he calls the office: "I'm stuck in traffic on I-630. Traffic is backed up for MILES. I'll be there as soon as I can." At 9AM he calls the office: "I'm stuck in traffic on I-630. Traffic is backed up for MILES. I'll be there as soon as I can." At 10AM he calls the office: ""I'm stuck in traffic on I-630. Traffic is backed up for MILES. I'll be there as soon as I can." This same call is repeated every hour until 1PM when he calls to say he's just going to head back home and try again tomorrow. He finally finds a way to turn around and head back. At 5PM he calls his wife: "I'm stuck in traffic on I-630. Traffic is backed up for MILES. I'll be there as soon as I can." The message is repeated every hour... There's some truth in the joke. Often urban traffic is just a lot of idling interspersed with a couple of seconds of hot throttle and brake lockup to change lanes. I'd like to know what the economy numbers are for situations like that.

    • NickS NickS on Nov 15, 2016

      That's why having public transportation options is so important. Nothing kills the joy of driving faster than having to commute in gridlock.

  • Fendertweed Fendertweed on Nov 15, 2016

    EPA estimates for our '09 Subaru Outback and '14 Impreza are just about right, less than a 5% variance for city, highway, and average MPGs. They were also right about on the mark for my '01 Audi A6 Avant over 110,000 miles of driving.

  • CanadaCraig You can just imagine how quickly the tires are going to wear out on a 5,800 lbs AWD 2024 Dodge Charger.
  • Luke42 I tried FSD for a month in December 2022 on my Model Y and wasn’t impressed.The building-blocks were amazing but sum of the all of those amazing parts was about as useful as Honda Sensing in terms of reducing the driver’s workload.I have a list of fixes I need to see in Autopilot before I blow another $200 renting FSD. But I will try it for free for a month.I would love it if FSD v12 lived up to the hype and my mind were changed. But I have no reason to believe I might be wrong at this point, based on the reviews I’ve read so far. [shrug]. I’m sure I’ll have more to say about it once I get to test it.
  • FormerFF We bought three new and one used car last year, so we won't be visiting any showrooms this year unless a meteor hits one of them. Sorry to hear that Mini has terminated the manual transmission, a Mini could be a fun car to drive with a stick.It appears that 2025 is going to see a significant decrease in the number of models that can be had with a stick. The used car we bought is a Mk 7 GTI with a six speed manual, and my younger daughter and I are enjoying it quite a lot. We'll be hanging on to it for many years.
  • Oberkanone Where is the value here? Magna is assembling the vehicles. The IP is not novel. Just buy the IP at bankruptcy stage for next to nothing.
  • Jalop1991 what, no Turbo trim?
Next